Jv001352

16’ x 93W” x 85H”

Parts Catalog

2016 Morgan olson body
2016 frEIgHTlInEr MT45 cHassIs

2016

PUblIsHEd 06.2016

WWW.Morganolson.coM

1.800.233.4823

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

2

3

TablE of conTEnTs & caTalog aPPlIcaTIon gUIdE

2

InTrodUcTIon

3

cab & EngInE box

4

sTEPs 

5

WIndsHIEld

6

InsTrUMEnT PanEl

7

Hood

8-9

sEaTs

10

floor

11

sIdEs

12-13

roof

14

rEar

15

sIdE door

16

sIdE door PockET

17

roll UP WIndoW

18

bUlkHEad

19

rEar doors

20-21

sTIffEnErs

22

bUMPErs

23

MIrrors & WIndsHEIld WIPErs

24-25

HEaTEr

26-27

MIscEllanEoUs

28-29

baTTEry box

30

Walk-In van coMMon fasTEnErs

31-35

ElEcTrIcal

36-37

WIrIng dIagraMs

38-57

table of Contents

This parts guide contains illustrations and part numbers for snap on package delivery cars and 
applies to bill of material # Jv001352 produced in 2016.

This book has been divided into chapters. Each chapter has illustrations with part numbers and de-
scriptions. When possible, each part is pointed out to help identify it. orientation references are from 
the rear of the vehicle facing forward. lH (lEfT Hand) is roadside and rH (rIgHT Hand) is curb-
side. 

optional parts assemblies may be included in product illustrations that were not installed as part of 
the original vehicle order. 

Procedure to order Parts

1. depending on the part desired, turn to the appropriate section.
2. locate the desired part on the illustration page(s) and note it’s part number.
3. contact a Morgan olson service Parts representative. Have part numbers readily available.
4. When placing orders, specify vehicle vIn number.
5. for roll-up door parts, please have door serial number available.

for WarranTy InforMaTIon call

 1-800-262-3437

any QUEsTIons or concErns sHoUld bE dIrEcTEd To yoUr sErvIcE

ParTs rEPrEsEnTaTIvE aT

1-800-233-4823

At Morgan Olson, our quest for quality and safety is ongoing and therefore the specifications on the 

product described herein may vary over time. Please contact Morgan olson for the latest product 

information and available safety features and options.

introduCtion

THIs caTalog aPPlIEs To THE folloWIng snaP on ldv vEHIclEs

4UZaaPdU7HcHv2147
4UZaaPdU9HcHv2148
4UZaaPdU0HcHv2149
4UZaaPdU7HcHv2150
4UZaaPdU9HcHv2151
4UZaaPdU0HcHv2152
4UZaaPdU2HcHv2153
4UZaaPdU4HcHv2154
4UZaaPdU6HcHv2155
4UZaaPdU8HcHv2156
4UZaaPdU5HcHv2163
4UZaaPdU7HcHv2164
4UZaaPdU9HcHv2165
4UZaaPdU0HcHv2166

4UZaaPdU2HcHv2167
4UZaaPdU4HcHv2168
4UZaaPdU6HcHv2169
4UZaaPdU2HcHv2170
4UZaaPdU4HcHv2171
4UZaaPdU6HcHv2172
4UZaaPdU8HcHv2173
4UZaaPdUxHcHv2174
4UZaaPdU1HcHv2175
4UZaaPdU3HcHv2176
4UZaaPdU5HcHv2177
4UZaaPdU7HcHv2178
4UZaaPdU9HcHv2179
4UZaaPdU5HcHv2180

4UZaaPdU7HcHv2181
4UZaaPdU9HcHv2182
4UZaaPdU0HcHv2183
4UZaaPdU2HcHv2184
4UZaaPdU4HcHv2185
4UZaaPdU6HcHv2186
4UZaaPdU8HcHv2187
4UZaaPdUxHcHv2188
4UZaaPdU1HcHv2189
4UZaaPdU8HcHv2190
4UZaaPdUxHcHv2191
4UZaaPdU6HcHv2205
4UZaaPdU8HcHv2206

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

4

5

Cab / engine box

stePs

item # Part #

desCriPtion

qty.

unit

1

47006630

clIP PlasTIc roUnd/HEad 1.32-1.34

27

Ea

2

098005502

EngInE box saddlE al .125x19.69x32.66

1

Ea

3

077050402

sHIM al .25x1.62x20.8

1

Ea

4

098005503

EngInE box sIdE roadsIdE al .102x21.24x27.96 lH

1

Ea

5

077050423

ToE board roadsIdE al .125x8.7x33.53 lH

1

Ea

6

077050419

ToE board dasH roadsIdE al .125x7.62x42.1 lH

1

Ea

7

1107270

sEal TrIM rUbbEr

8

fT

8

098005400

EngInE box ToP al .125x15.86x32.75

1

Ea

9

098005501

EngInE box HoUsIng al .102x20.85x32.55 rH

1

Ea

10

098005462

dasH PanEl al .102x29.44x28

1

Ea

11

098005472

dasH Wall cUrbsIdE al .125x25.9x62.92

1

Ea

12

077050408

dasH Wall roadsIdE al .125x8.84x27.25

1

Ea

13

8502001

cornEr casTIng cUrbsIdE

1

Ea

14

8502000

cornEr casTIng roadsIdE

1

Ea

15

083023402

WIndsHIEld raIl al 851100x89

1

Ea

16

083005418

sUPPorT raIl roadsIdE al .102x5.74x8.27 lH

1

Ea

17

083005419

sUPPorT raIl cUrbsIdE al .102x5.74x8.27 rH

1

Ea

18

077050400

sTIffEnEr roadsIdE al .125x10.93x17.81 lH

1

Ea

19

077050401

sTIffEnEr cUrbsIdE al .125x10.93x17.81 rH

1

Ea

20

093005512

dasH sHElf al .125x13.74x89

1

Ea

21

093005421

cab skIrT roadsIdE al .070x27.28x30.57 lH

1

Ea

22

108005401

cab skIrT cUrbsIdE al .070x27.28x30.57 rH

1

Ea

23

47008545

vEnT 2 Way HInglEss

1

Ea

24

47008548

vEnT gaskET

1

Ea

25

077050406

gUssET ToE board cUrbsIdE al .125x5.33x14.88 rH

1

Ea

26

077050411

fIllEr saddlE  al .125x11.79x14.49

1

Ea

27

077050446

HEEl scUff PlaTE ald  .125x7x13.38

1

Ea

28

47007859

HIngE offsET

2

Ea

29

1113336

laTcH

2

Ea

30

117028400

sHIM EngInE box

2

Ea

31

118028400

lId EngInE box al .102x20.28x34.23

1

Ea

2

29

4

28

3

8

20 15

19

17

13

22

11

10

9

25

30

26

27

5

6

14

16

21

24

23

18

12

30

31

1

7

11

10

14

4

12

8

2

3

1

7

15

6

7

5

item #

Part#

desCriPtion

qty.

unit

1

077240400

cross MEMbEr cEnTEr al 456106x41

1

Ea

2

088024246

sTEP assEMbly cab roadsIdE

1

Ea

3

098024202

sTEP assEMbly cab cUrbsIdE

1

Ea

4

006324498

HIngE al .075x1.12x1.75x21

1

Ea

5

107024419

lId baTTEry ald .125x22.25x24.82

1

Ea

6

96724608

Pad daMPEnIng 45200007x9x20

1

Ea

7

1113334

laTcH sTraP

2

Ea

8

084024415

rIsEr cornEr  al .125x3.5x3.61

1

Ea

9

40900080

sTUd

4

Ea

10

40900081

groMMET Half

4

Ea

11

40900082

sPrIng

4

Ea

12

077024402

anglE TrIM floor  al .102x6.35x38.7

1

Ea

13

108024201

floor TransvErsE WEldMEnT

1

Ea

14

47001053

grab raIl fIxEd  yElloW

1

Ea

15

077050402

sHIM al .25x1.62x20.8

1

Ea

16

083019413

TrIM MaT @ o/ln ald .08x2.29x63.41

1

Ea

17

103019402

TrIM ToEboard   ald  .08x2.63x30.58 lH

1

Ea

18

090019403

TrIM sTEP              ald .08x2.69x26.5   rH

1

Ea

19

090019401

TrIM ToEboard   ald .08x2.69x26.5   rH

1

Ea

20

42002055

MaT floor soUnd absorbIng 60x95

2

Ea

21

47006630

clIP PlasTIc roUnd HEad

12

Ea

12

14

19

18

16

17

20

21

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

6

7

windshield

item # Part #

desCriPtion

qty. unit

1

088055204

WIndsHIEld assEMbly 85H93W no vEnT

1

Ea

2

083023402

WIndsHIEld raIl 93W al 851100x89

1

Ea

3

088055406

fraME WIndsHEIld cUrbsIdE al .102x53.45x70.25

1

Ea

4

077055404

sTIffnEr W/s al 450540x44.25

2

Ea

5

077055401

PosT W/s cEnTEr al 450540x44.84

1

Ea

6

088055405

fraME WIndsHEIld roadsIdE al .102x53.45x69.95

1

Ea

7

077055402

gUssET fraME W/s al .125x6.49x7.27

1

Ea

8

998555329

gUssET fraME W/s al .125x4.6x9.19

1

Ea

9

96756400

glass WIndsHIEld

2

Ea

10

006756400

glass sIdE TrIanglE

2

Ea

11

44004303

WEaTHEr sTrIPPIng 1660 x147.5

2

Ea

11

44004309

WEaTHEr sTrIPPIng 1660 x86.25

2

Ea

12

47006610

PUsH-In clIP

32

Ea

13

117076400

sHElf ovErHEad sToragE  al .102x14.8x87.9

1

Ea

14

117076401

brackET MoUnTIng al .102x2x4.96 lH

1

Ea

15

117076402

brackET MoUnTIng al .102x2x4.96 rH

1

Ea

instrument Panel

2

3

4

5

6

7

8

13

1

9

10

19

12

11

14

15

item #

Part #

desCriPtion

qty.

unit

1

088027200

InsTrUMEnT PanEl WEldMEnT

1

Ea

2

107027403

bracE I/P al .102x3.75x8.43

1

Ea

3

002027423

brackET sHIfTEr sTl 11gax4.87x6.43

2

Ea

4

093027402

brackET sTIffEnEr al .125x1.91x12.66

1

Ea

5

47008545

vEnT 2 Way HInglEss

1

Ea

6

47008548

gaskET vEnT

1

Ea

7

006327202

sPacEr IgnITIon sWITcH al .102x1.5x1.5

1

Ea

8

46023506

PlUg Hl rockEr sWITcH black

3

Ea

9

555001416

PanEl conTrol Hvac

1

Ea

10

098027406

PlaTE covEr InsTrUMEnT PanEl al .102x4.98x8.25

1

Ea

11

44000119

PlUg Hl black

1

Ea

12

1111513

PlUg Hl black

1

Ea

13

46026378

rEcEPTIclE 12v PoWEr W/TETHEr ss body

2

Ea

14

098027402

PlaTE adaPTor  al .102x8.25x16

1

Ea

15

47000100

sHElf al. Work sTaTIon 30”

1

Ea

16

088027413

I/P End cEnTEr al .102x8.4x18.5

1

Ea

17

47009653

cEnTEr consolE black

1

Ea

18

107027406

PlaTE covEr I/P al .07x3.63x7.75

1

Ea

19

46026366

lIgHTEr 12v

1

Ea

10

9

2

11

12

1

3

7

5

2

6

13

4

14

5

6

3

16

8

17

7

8

16

18

19

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

8

9

hood

22

21

5

10

2

3

34

15

4

1

14

6

4

11

7

8

9

12

17

18

19

20

21

13

4

item # Part #

desCriPtion

qty.

unit

1

118017202

Hood assEMbly

1

Ea

2

088017414

Hood skIrT al .07x30.78x33.11 roadsIdE

1

Ea

3

088017415

Hood skIrT al .07x30.78x33.11 cUrbsIdE

1

Ea

4

47007852

HIngE assEMbly

2

Ea

5

108017401

PanEl Hood fcc al.07x53.36x72

1

Ea

6

088017416

coWl Hood roadsIdE al .07x15.91x22.28

1

Ea

7

088017417

coWl Hood cUrbsIdE al .07x15.91x22.28

1

Ea

8

95817312

gUssET cornEr roadsIdE al .07x13.52x14.72

1

Ea

9

95817313

gUssET cornEr cUrbsIdE al .07x13.52x14.72

1

Ea

10

45100057

cornEr casT knEE coWl fronT roadsIdE

1

Ea

11

45100058

cornEr casT knEE coWl fronT cUrbsIdE

1

Ea

12

088017420

sTIffEnEr Hood al 450015x68.62

1

Ea

13

45001500

brackET Hood al Hd x69.77

1

Ea

14

45100060

caP coWl End roadsIdE

1

Ea

15

45100061

caP coWl End cUrbsIdE

1

Ea

17

91617304

PlaTE TaP al .188x2x2.69

2

Ea

18

96717312

sHIM al .125x.62x1.88

2

Ea

19

115017403

sTIffEnEr Hood roadsIdE

1

Ea

20

115017404

sTIffEnEr Hood cUrbsIdE

1

Ea

21

90187300

grab HandlE .5dIax15.7

1

Ea

22

45700101

MEsH grIllE 20.5x38.81

1

Ea

ns

088017423

anglE sUPPorT grIllE 450186x69.62

1

Ea

ns

088017421

sUPPorT grIllE anglE 450180x22.8

2

Ea

ns

088017441

anglE HorZ 450186x69.62

1

Ea

ns

44004077

sEal TaPE #1458bTxfT

4.42

fT

38

50

40

30

48

51

35

44

37

41

52

49

47

33

43

36

31

39

item # Part #

desCriPtion

qty.

unit

29

44002004

bUMPEr rUbbEr Hood rEsT

2

Ea

30

47006116

gas sPrIng WITH lock 140lb 20/12 Igs

1

Ea

31

47006117

gas sPrIng WITH oUT lock  140lb 20/12 Igs

1

Ea

32

40900019

sTUd ball sUsPEnsIon

4

Ea

33

96713300

sToP anglE Hood rEsT

2

Ea

34

47000613

laTcH Hood 

2

Ea

35

077150400

brackET sUPPorT Hood rEsT

2

Ea

36

124016401

brackET gas sPrIng al.125x3.6x16.48 roadsIdE

1

Ea

37

124016402

brackET gas sPrIng al.125x3.6x16.48 cUrbsIdE

1

Ea

38

124016403

brackET Hood loWEr al.188x2.85x6.4 cUrbsIdE

1

Ea

39

124016404

brackET Hood loWEr al.188x2.85x6.4 roadsIdE

1

Ea

40

47004137

WasHEr boTTlE WITH PUMP

1

Ea

41

003705413

WasHEr boTTlE MoUnTIng PlaTE

1

Ea

42

45700101

MEsH grIll 20.5x38.81

1

Ea

43

077260400

sPlasH Pan roadsIdE

1

Ea

44

077260404

sPlasH Pan cUrbsIdE

1

Ea

45

43000903

Hood ProPEr InsTrUcTIons labEl

1

Ea

46

088017255

sUPPorT assEMbly grIll

1

Ea

47

088017433

sUPPorT sPlasH Pan al .102x16.07x16.83

1

Ea

48

088017436

sUPPorT sPlasH Pan al .102x16.07x16.83

1

Ea

49

088017427

sPlasH Pan al .102x19.43x26.95 roadsIdE

1

Ea

50

088017430

sPlasH Pan al .102x19.93x26.95 cUrbsIdE

1

Ea

51

088017437

sTraP al .125x2.98x25.76 roadsIdE

1

Ea

52

088017438

sTraP al .125x2.98x25.76 cUrbsIdE

1

Ea

32

45

33

35

39

37

38

36

29

30

31

34

41

42

40

44

43

46

51

52

50

48

49

47

hood

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

10

11

seats

item # Part #

desCriPtion

qty.

unit

1

47004656

sEaT drIvEr cloTH lUMbar

2

Ea

2

47011201

arM rEsT sEaT 3PnT rH

1

Ea

3

47011200

arM rEsT sEaT 3PnT lH

1

Ea

4

47004332

PEdEsTal sEaT UPPEr 3PnT/In fcc

1

Ea

5

98M582030

bracE sUPPorT sTEEl 7gax9.43x23.43

1

Ea

6

47012658

sEaT soc/PEdEsTal basE frE 3PnT TIlT

1

Ea

7

47007914

s/bElT black   W/o TEaTHErs

1

Ea

8

47004348

JUMP sEaT foldIng

1

Ea

9

47004349

back rEsT JUMP sEaT

1

Ea

10

91614300

anglE floor  al  .188x2.84x19.1

1

Ea

11

47004504

sEaT bElT black W/o TEaTHErs

1

Ea

item # Part #

desCriPtion

qty

unit

1

083033509

bEaM @ o lInE

1

Ea

2

001730412

anglE sTEP

1

Ea

3

45040103

bEaM al floor M-fEM 9x89.38 and 92.38

8

Ea

4

45040503

bEaM al floor M-fEM 8.5x92.38

2

Ea

5

45051003

bEaM al floor fEM-laP 7x92.38

2

Ea

6

45040203

bEaM al floor M-fEM 8x89.38 and 92.38

5

Ea

7

45030300

anglE aTTaTcH floor/sIdE

1.81

Ea

8

7504176

gUssET floor To sIdE  al .102x12.1x12.1

5

Ea

9

95869302

anglE W/box aTTaTcH (roadsIdE sHoWn)

2

Ea

10

118032202

WHEEl box assEMbly

2

Ea

11

06M106008

bEaM floor al 8x450402x40.62

2

Ea

12

95869303

bEaM floor al 9x450401x40.6

2

Ea

13

95869304

bEaM floor al 8x450407x40.6

1

Ea

14

45051003

bEaM floor rIbbEd fEMalE/laP    7x92.25

1

Ea

15

03M553071

anglE aTTaTcH W/box

.5

Ea

16

088033401

fIllEr PlaTE al .125x6.68x92.38

1

Ea

17

45059200

droP sIll

1

Ea

18

108012409

PlaTE sUPPorT accEss covEr al .125x10.3x13.5

1

Ea

19

108012400

covEr accEss PlaTE al.  .125x9.61x11.62

1

Ea

20

40900080

sTUd accEss covEr fasTEnEr

4

Ea

21

40900081

Half WasHEr accEss covEr fasTEnEr

4

Ea

22

40900082

sPrIng accEss covEr fasTEnEr

4

Ea

1

5

7

4

6

2

3

floor

15

5

2

1

7

10

7

10

5

16

17

3

3

4

4

13

12

5

1

17

3

13

4

7 

8

6

7

15

7

6

14

12

11

9

8

11

10

6

18

19

20

21

22

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

12

13

side roadside

item #

Part #

desCriPtion

qty

unit

1

123046400

sIdE UPPEr  al .102x60x242.31 dlH

1

Ea

2

168045400

sIdE loWEr al .102x37.5x242.31 dlH

1

Ea

3

088044403

door PosT boTToM (door PosT ToP - 088044402)

1

Ea

4

088039327

rUbraIl al 450002x238.31 dlH

1

Ea

5

1100800

End caP forWard

0

Ea

6

1100799

End caP rEar

2

Ea

7

7600165

fIllEr PlaTE rUbraIl

1

Ea

8

1100486

anglE sTIffEnEr .125x1x1x192

1

Ea

9

45800093

glass WIndoW roll UP

1

Ea

10

7504176

gUssET floor To sIdE al .102x12.1x12.1

5

Ea

11

130009201

baTTEry box assEMbly

1

Ea

12

47001498

HandlE T  sTaInlEss

1

Ea

13

47000921

door HoldEr

1

Ea

14

89367380

drIP raIl ovEr WIndoW al 450006x35.32

1

Ea

15

130009405

HIngE - baTTEry box

1

Ea

side Curbside

item #

Part #

desCriPtion

qty

unit

1

098038405

sIdE UPPEr  al  .102x60x201.31 

1

Ea

2

168037400

sIdE loWEr al  .102x37.5x201.31

1

Ea

3

088044403

door PosT boTToM   (door PosT ToP - 088044404)

1

Ea

4

088039305

rUbraIl al 450002x197 dlH

1

Ea

5

1100800

End caP forWard

1

Ea

6

1100799

End caP rEar

1

Ea

7

7600165

fIllEr PlaTE rUbraIl

1

Ea

8

1100486

anglE sTIffEnEr .125x1x1x192

1

Ea

9

45800103

WIndoW slIdIng sasH

1

Ea

10

45900001

PlUg Wood rUb raIl

Ea

11

098022401

skIrT TaIl cUrbsIdE al .07x5.76x36.83

1

Ea

12

077400401

b PosT cUrbsIdE al 450274x99.62 rH

1

Ea

13

095012410

dEf Tank door al .102x6.89x7.02

1

Ea

14

47007888

HIngE

2

Ea

15

1107102

rUbbEr bUMPEr

1

Ea

16

117012400

fUEl fIll door al .102x5.54x5.86

1

Ea

17

108012403

brackET sUPPorT al .125x4.5x11.87

1

Ea

18

108012404

sPlasH Pan fUEl fIll al .07x8.39x20.34

1

Ea

19

108012405

sPlasH Pan fUEl fIll al .07x19.5x23.82

1

Ea

20

82312025

sUPPorT sPlasH Pan al .07x1.5x2.84

1

Ea

21

82312026

sUPPorT fUEl fIll al .102x1x3.52

1

Ea

22

47007038

nEck fUEl fIll

1

Ea

4

3

2

8

3

6

11

1

6

4

7

5

6

10

9

11

12

11

6

2

1

5

4

4

3

3

9

12

7

15

13

13

14

15

16

6

5

13

8

18

19

20

21

17

22

14

10

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

14

15

baCK

4

1

6

7

1

5

2

2

5

8

10

9

9

11

12

13

6

roof

item #

Part #

desCriPtion

qty

unit

ns

1100010

roof skIn

19.98

fT

2

91083303

roof boW sTEEl 14ga 450358x89.12

11

Ea

3

083010420

roof raIl 22’ 456144x309.25  roadsIdE

1

Ea

4

083010421

roof raIl 22’ 456144x309.25  cUrbsIdE

1

Ea

5

088010512

raIl InTErlock roadsIdE al 450140x237.25l

1

Ea

6

088010513

raIl InTErlock cUrbsIdE al 450140x237.25r

1

Ea

7

89310478

roof boW @ o lInE 14ga glnx13.54x89.12

1

Ea

8

077100400

cornEr casTIng roadsIdE

1

Ea

9

077100401

cornEr casTIng cUrbsIdE

1

Ea

10

89310506

InTErlock  roof nosE al45014x82.38

1

Ea

11

89310507

InTErlock roof TransoM al450140x79.88

1

Ea

12

083010400

roof nosE

1

Ea

6

4

10

3

5

12

4

2

6

10

11

7

9

12

8

3

7

2

5

11

3

3

14

item # Part #

desCriPtion

qty.

unit

1

168050400

cHannEl PosT cornEr  al 450359x96.19

2

Ea

2

168050401

PanEl back al .102x26.63x88.44

2

Ea

3

77552018

HEadEr back 93W al 450138x92

1

Ea

4

083053605

sIll rEar 93W al 450024x88.75

1

Ea

5

45100009

cornEr casT lH

1

Ea

6

45100010

cornEr casT rH

1

Ea

7

083050410

TransoM  al 450254x91.62

1

Ea

8

004051401

PlaTE sTrIkEr d/r loWEr 11gassx4.33x9

1

Ea

9

083050461

PosT HIngE al 450011x77.13

2

Ea

10

90650305

gUssET UPPEr al .125x5.12x6.59 rH

1

Ea

11

90650304

gUssET UPPEr al .125x5.12x6.59 lH

1

Ea

12

96750313

anglE clIP al  450196x1

2

Ea

13

45100106

sTrIkEr brZc d/r

1

Ea

14

118050202

cHannEl PosT WEldMEnT for lIfTgaTE

2

Ea

ns

87144300

anglE MoUnTIng rEar cornEr PosT al  450180x76

2

Ea

13

roof a/C reinforCement

 item #

Part #

desCriPtion

qty.

unit

ns

46027584

coUPlIng al rIg condUIT .5In

1

Ea

ns

168010414

rEInforcEMEnT rf a/c c-cHannEl al .102x3.09x14

2

Ea

ns

46027583

nIP al rIg cdT .5x2

1

Ea

16

168010412

PlaTE rEInforcEMEnT  al .102x21.70x25.88

1

Ea

17

072010403

cHannEl  a/c  al .102x3.08x17.5

2

Ea

ns

46027506

bUsHIng PlasTIc Elc InsUlaTIon .5In

1

Ea

19

168010413

PlaTE rEInforcEMEnT  al .102x24.15x25.88

1

Ea

16

19

17

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

16

17

side door

item #

Part #

desCriPtion

qty.

unit

1

1113393

HandlE sIdE door cHroME (rEMovablE cylIndEr)

1

Ea

2

96760307

HangEr door  al  450515x40.09

1

Ea

3

47006595

bEarIng sr311-214 & rT311-278

4

Pr

4

148060200

sIdE door assEMbly

1

Ea

5

45200206

sPacEr anTI raTTlE 

2

Ea

6

1110001

WIndoW  (WEaTHEr sTrIP - 44004229) 

1

Ea

7

47002766

door gUIdE nylon

1

Ea

8

96760318

clIP anTI raTTlE

2

Ea

9

087181

kason sPacEr

1

Ea

10

1113016

laTcH

1

Ea

11

45100093

sTrIkEr bronZE casT d/s rr

2

Ea

12

45100094

brackET sTrIkEr

1

Ea

13

44002011

rUbbEr bUMPEr

1

Ea

14

1113383

cylIndEr rEMovablE  W/kEy

1

Ea

15

44008050

sEal brUsH TyPE b 1x41.95”

1

Ea

16

148060406

PanEl door loWEr al .07x39.4x40.02

1

Ea

door PoCKet 

item # Part #

desCriPtion

qty.

unit

1

118041410

PanEl door PockET  al .102x42.26x87.65 rH

1

Ea

2

96741303

cHannEl HEadEr  al  450256x75 rH

1

Ea

3

98741353

nosE sTEP  al  450247x61.29  rH

1

Ea

4

077410401

PosT door al  450294x102.43 rH

1

Ea

5

077410405

PanEl HEadEr al .102x19.51x42.39 rH

1

Ea

6

96741202

Track door assEMbly UPPEr  

1

Ea

7

45100049

gUssETT  al casT HEadEr cHannEl To d/PsT rH

1

Ea

8

45100105

door PosT al casT lWr rH

1

Ea

9

001741408

rEInforcEMEnT a PosT al .125x1.53x8.04 rH

1

Ea

10

44008050

sEal brUsH TyPE b 1x83.9

1

Ea

11

44004060

sEal brUsH TyPE c 1.5x82

1

Ea

12

1107270

sEal door EdgE

8

fT

13

44004104

sEal door forWard 89.25”

1

Ea

14

083042401

sTIffEnEr HEadEr al 450328x73.75 rH

1

Ea

15

96742302

ZEE clIP al.102x3x9.57

1

Ea

ns

87146300

anglE door PockET al 450194x58.25

1

Ea

17

97r653002

sTrIkEr WEldMEnT

1

Ea

7

8

11

10

1

5

7

3

2

5

8

5

8

10

9

9

12

15

13

14

3

4

3

2

1

4

5

8

9

3

4

9

8

6

7

7

2

15

14

10

6

11

6

12

13

16

17

x

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

18

19

roll uP window

item #

Part #

desCriPtion

qty.

unit

1

088066001

roll UP WIndoW InsTallaTIon

1

Ea

2

45800079

fraME assEMbly

1

Ea

3

47007526

WIndoW rEgUlaTor

1

Ea

4

47007522

HandlE WIndoW rEgUlaTor

1

Ea

5

084024422

covEr loWEr al .102x3.43x28.73

1

Ea

6

084024423

covEr UPPEr al .102x2.25x13

1

Ea

7

45800093

glass  roll UP WIndoW .125x28.43x32.59

1

Ea

ns

89367380

drIP raIl ovEr WIndoW al 450006x35.32

1

Ea

9

088066400

PanEl rEgUlaTor  al .102x33.19x36.20 dl

1

Ea

10

998566407

sTIffEnEr ZEE rEar al .102x2.94x62.73 l/r

1

Ea

11

998566419

fElT glass x28.12

1

Ea

1

2

3

5

6

bulKhead

19

item # Part #

desCriPtion

qty.

unit

1

138070473

PanEl bHd al.102x37.84x77.38 dlH

1

Ea

2

138070472

PanEl bHd al.102x27.13x77.38 rH

1

Ea

3

138070474

ZEE HEadEr bHd al.102x14.65x92.4

1

Ea

4

088070201

door assEMbly bHd n/Wdo UPr Hndl Pos

1

Ea

5

088070439

PlaTE HangEr al 450515x27.38

1

Ea

6

47006595

bEarIngs sEalEd

4

Pr

7

088070438

cHannEl bHd UPPEr al 450502x63.08

1

Ea

8

088070433

sPacEr door bHd al .125x4.6x10.02

1

Ea

9

005770200

Track door assEMbly

1

Ea

10

06M202043

sHIM HandlE door al .125x1x7

1

Ea

11

1113016

lock MEcH InnEr d/s

1

Ea

12

96770312

JaMb al 450326x74.37 rH

1

Ea

13

088070482

sPacEr bHd 1101200x1.75

2

Ea

14

002069406

sTIffEnEr ZEE alE450043x72.12

1

Ea

15

088070443

PlaTE bHd al .055x3.65x8.29 rH

1

Ea

16

088070431

brackET sTrIkEr sTl 7gax3.5x6.32 lH

1

Ea

17

088070432

brackET sTrIkEr sTl 7gax3.5x11.77 rH

1

Ea

18

128070481

gUIdE door bHd al 45041402x47.88

1

Ea

19

088070434

WEar sTrIP  door boTToM

1

Ea

20

44002011

bUMPEr rUbbEr

2

Ea

21

45200208

door cHock nylon

1

Ea

22

5903152

door sToP

1

Ea

23

133069400

sTIffEnEr bUlkHEad for JUMP sEaT al 450043x72.12

1

Ea

24

083069404

sTIffEnEr bUlkHEad for JUMP sEaT al 450043x72.12

1

Ea

8

20

22

17

16

21

13

10

6

5

6

11

18

1

15

9

7

12

2

3

24

7

18

12

9

23

14

4

9

3

7

4

5

6

11

4

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

20

21

rear door

rear door

rear door assemblies

item #

desCriPtion

Part #

1

door asEMbly rEar  lH   

84352330

2

door asEMbly rEar  rH

84352323

3

cablE

47000541

4

HIngE sTraP W/ZErk

47007900  x6

5

dUsT Pan

7500036

6

sHIM laTcH door

110051400

7

laTcH fIngEr PUll

1113021

8

gUIdE rod

1112011

9

sHIM gUIdE

7400126

10

door HoldErs

1113035

11

HandlE door InT.

1113015

12

HandlE door ExT.

47001176

13

cylIndEr lock

47001181

14

HandlE door flaT InT.

47000669

15

sHIM MEcHInIsM

7401809

16

rod UPPEr

47000539

ns

rod loWEr

47000549

17

sEal sPongE   P/n 1107047  rH

17.12 fT

17

sEal sPongE   P/n 1107047  lH

10.56 fT

18

sTrIkEr bronZE UPPEr

45100106

19

HandlE MEcHInIsM

47000547

20

brackET sTrIkEr

148133403

3

10

11

9

6

16

8

7

18

6

7

8

5

9

13

12

4

14

15

1

2

19

17

20

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

22

23

item #

Part #

desCriPtion

qty.

unit

1

103048410

sTIffEnEr alE 450092x79

4

Ea

2

103048411

sTIffEnEr alE 450092x79

8

Ea

3

103048412

sTIffEnEr alE 450092x69.69 abovE W/box

2

Ea

4

103048413

sTIffEnEr alE 450092x69.69 abovE W/box

2

Ea

5

103048414

sTIffEnEr bEsIdE W/box  al   450092x7.75

2

Ea

6

103048415

sTIffEnEr rr UPr   alE 450092x26 lH

1

Ea

7

103048416

sTIffEnEr rr UPr   alE 450092x26 rH

1

Ea

8

103048417

sTIffEnEr rr lWr   alE 450092x14.19 lH

1

Ea

9

103048418

sTIffEnEr rr lWr   alE 450092x14.19 rH

1

Ea

stiffeners

bumPers

item #

Part #

desCriPtion

qty.

unit

1

90506341

PlaTE HangEr bUMPEr

2

Ea

2

n/a

fronT bUMPEr sUPPlIEd by cHassIs Mfg.

1

Ea

8

2

6

1

9

3

1

5

2

4

7

2

5

5

5

5

1

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

24

25

mirrors and wiPers

item #

Part #

desCriPtion

qty.

unit

1

mirrors

2

47006150

MIrror assEMbly ss HEaTEd roadsIdE

1

Ea

3

47006151

MIrror assEMbly ss HEaTEd cUrbsIdE

1

Ea

4

windshield wiPer 

5

1107122

HosE .188 Id  WsW

12

fT

6

083055454

brackET WIPEr MoTor

1

Ea

7

1101694

TEE WsWa U/T

1

Ea

8

47004188

WIPEr sysTEM Tblr 2 PIvoT

1

Ea

9

146363002

WIPEr arM WITH bladE

1

Ea

10

47004134

bladE 24In black

1

Ea

11

47004206

arM WsW WET 22In radIal black

1

Ea

12

47004505

rsvr W/PUMP WsWa

1

Ea

13

003705413

brackET MoUnTIng rsvr

1

Ea

14

46021115

clIP body largE Pan

1

Ea

15

47005901

nUT

2

Ea

16

47005902

PIvoT covEr

2

Ea

17

47005903

sPacEr

2

Ea

18

47005900

MoTor WIndsHIEld WIPEr

1

Ea

1

2

3

5

6

7

4

6

9

10

11

8

12 

13

14

15

16

17

15

16

17

18

mirror assembly

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

26

27

heater

item # Part #

desCriPtion

qty

unit

1

555001108

HEaTEr corE assEMbly  WITH fIlTEr

1

Ea

2

47008760

HEaTEr coIl W/gaskET & claMP 

1

Ea

3

47008753

door W/sEal

1

Ea

4

47008754

bloWEr HoUsIng

1

Ea

5

47008755

bloWEr adaPTEr

1

Ea

6

47008732

rEsIsTEr cagE

1

Ea

7

47008357

rEsIsTEr

1

Ea

8

47008756

bloWEr MoTor

1

Ea

9

47008757

bloWEr WHEEl

1

Ea

10

47008730

vEnT TUbE

1

Ea

11

47008731

vEnT TUbE adaPTor

1

Ea

12

47008716

rElay

1

Ea

13

47008768

HarnEss

1

Ea

14

47008580

forMEd HEaTEr HosE

2

Ea

15

555002053

valvE WaTEr

1

Ea

17

090080401

dUcT fT dUMP sPEcIal  (MoUnTIng PlaTE - 005780402)

1

Ea

18

555001416

conTrol PanEl Hvac

1

Ea

10

11

4

3

1

2

12

13

6

7

5

9

8

7

14

1

15

17

heater

item # Part #

desCriPtion

qty

unit

1

47008706

knob

2

Ea

23

47008735

knob

1

Ea

2

47008707

dEcal

1

Ea

3

47008708

lIgHT PanEl

1

Ea

4

47008709

conTrol PanEl

1

Ea

5

47008700

bloWEr sWITcH

1

Ea

6

47008710

PoTEnTIoMETEr sWITcH

2

Ea

7

47008711

HarnEss IllUMInaTIon W/bUlbs

1

Ea

8

47008712

HarnEss bloWEr MoTor

1

Ea

9

555001723

dEfrosT dUcT cUrbsIdE

1

Ea

10

555001724

dEfrosT dUcT roadsIdE

1

Ea

11

093080400

Hold doWn PlaTE dEfrosTEr dUcTs

4

Ea

ns

555001523

HosE dEfrosTEr 2.5x16

2

Ea

13

555001524

HosE dEfrosTEr 2.5x30

2

Ea

ns

555001525

HosE dEfrosTEr 2.5x38

1

Ea

15

555002003

collEr frEsH aIr InTakE 

1

Ea

16

555001715

lUvEr ball

6

Ea

17

555001321

dUcT Hvac

1

Ea

18

107027405

brackET HEaTEr vEnT

1

Ea

20

555001533

HosE bloWEr HEaTEr/dEfrosTEr 5”x7.5”

1

Ea

21

005780402

MoUnTIng PlaTE

1

Ea

22

002080400

brackET HEaTEr conTrol al .102x3x11.67

1

Ea

1

2

3

4

5

6

7

8

9

10

11

16

17

18

20

21

22

23

13

15

555001416

18

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

28

29

misCellaneous

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

item #

Part #

desCriPtion

qty.

unit

1

46025017

rEflEcTor 2.88 rEd

1

Ea

2

46025018

rEflEcTor 2.88 aMbEr

2

Ea

3

008300401

labEl fUsE block lH

1

Ea

4

008300402

labEl fUsE block rH

1

Ea

5

083092404

covEr fUsE cEnTEr al.102x4x4.13

1

Ea

6

102084499

brackET MoUnTIng fUsE box al.102x4x12.78

1

Ea

7

46026311

TyclaMP #10 x 7.5

1

Ea

8

1107072

groMMET

1

Ea

9

1107109

groMMET  0.375x0.125x.0625

1

Ea

10

44000052

groMMET  .688x.125x1

1

Ea

11

40900081

groMMET Half

4

Ea

12

46004402

groMMET roUnd black 4In laMP

6

Ea

13

46004403

groMMET oblong black laMP

2

Ea

14

44000800

MUd flaPs ldv black  24x26

1

Pr

15

7504428

rETaInEr MUd flaP

2

Ea

16

80795014

anglE rETaInEr MUd flaP

2

Ea

17

138077401

brackET sUPPorT al .102x4.61x24.11

1

Ea

18

138077403

brackET sUPPorT al .102x2.37x13.29

1

Ea

19

138077405

brackET rETaInEr al .188x5x20

1

Ea

20

1113334

laTcH baTTEry lId

1

Ea

21

47000613

laTcH Hood

1

Ea

22

1113336

laTcH EngInE box

1

Ea

23

093116410

InsUlaTIon dasH Wall

1

Ea

24

098005404

InsUlaTIon E/bx42002056x14.28x31.29

1

Ea

25

098005405

InsUlaTIon E/bx42002056x15.09x33.05

1

Ea

26

098005406

InsUlaTIon E/bx42002056x21.25x30.59

1

Ea

27

098005407

InsUlaTIon E/bx42002056x19.58x30.72

1

Ea

28

098028401

InsUlaTIon E/bx42002056x13.55x28.25

1

Ea

27

25

28

26

24

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

item #

Part #

desCriPtion

qty.

unit

1

148133403

brackET sTrIkEr rEar door al .102x1.4x7.96

1

Ea

2

97r653020

PlaTE sTrIkEr sTl 11gax1.47x8

1

Ea

3

1113035

door HoldEr rEar 3”  M/fEM

2

kIT

4

1113382

door HandlE

1

Ea

5

47001149

gaskET  door HandlE

1

Ea

6

1113383

cylIndEr lock WITH kEy

1

Ea

7

47001189

HandlE bUlkHEad door

1

Ea

8

088070482

sPacEr door HandlE

1

Ea

9

47001181

cylIndEr rEMovablE bUlkHEad door HandlE

1

Ea

10

11007087

groMMET  HEaTEd MIrrors

4

Ea

11

47009600

carPET bUlkHEad grEy

18.5

fT

12

47007038

nEck fUEl fIll

1

Ea

13

46004708

brackET MoUnTIng TEMP laMPs

2

Ea

14

1107102

rUbbEr bUMPEr door

1

Ea

15

165092400

brackET MoUnTIng TEMP laMP (lIcEnsE PlaTE)

1

Ea

16

Ea

17

Ea

18

Ea

19

Ea

20

Ea

21

Ea

22

Ea

23

Ea

24

Ea

24

misCellaneous

30

Z

c

Zinc 

c

oated

ZP

Zinc Plated

y

y

ellow

gr

g

rade

r

oH

s

as

9100

c

 

Iso

 9001:2008

as

TM 

f

593

c

a

merican 

s

tandards 

Measurements Specifications

g

rade 8

Medium 

c

arbon 

a

lloy 

s

teel

g

rade 5

Medium 

c

arbon 

s

teel

g

rade 2

l

ow or Medium 

c

arbon 

s

teel

g

enuine 

o

EM Parts 

  1.800.233.4823

www

.morganolsonparts.com

hex

 C

a

P

 s

C

rews

s

ize

d

escription

t

hread

l

engths

s

tandard

.62

3/4”

1”

1-1/4”

1-1/2”

1-3/4”

2”

2-1/2”

3”

3-1/4”

4”

1/4” Hex 

c

ap 

s

crew

gr

5 Z

c

/ro

20

1

1

17009

1/4” Hex 

c

ap 

s

crew

gr

5 Z

c

/r

oH

s

20

85743007

1

101688

1

1

17818

1/4” Hex 

c

ap 

s

crew

18-8 

s

tainless

20

1

1

17816

85743006

1

1

17010

1/4” Hex 

c

ap 

s

crew

as

TM 

f

593

c

20

1

1

17819

5/16” Hex 

c

ap 

s

crew

18-8 

s

tainless

18

1

1

17804

5/16” Hex 

c

ap 

s

crew

gr

8 Z

c

/y

18

1

1

17045

40300737

5/16” Hex 

c

ap 

s

crew

as

TM 

f

593

18

1

1

17803

1

1

17059

5/16” Hex 

c

ap 

s

crew

gr

5 Z

c

/r

16

1

1

17837

3/8” Hex 

c

ap 

s

crew

gr

8 Z

c

/y

18

1

1

17049

1

1

17055

3/8” Hex 

c

ap 

s

crew

gr

8 Z

c

/y

16

1

1

17843

3/8” Hex 

c

ap 

s

crew

gr

5 Z

c

/ro

16

47012646

1

1

17097

051

166

1

1

17000

3/8” Hex 

c

ap 

s

crew

gr

5 Z

c

/r

oH

s

16

40300056

40300054

40300058

05125

1

1

17040

05128

3/8” Hex 

c

ap 

s

crew

as

TM 

f

593

c

16

1

1

17805

1

1

17052

7/16” Hex 

c

ap 

s

crew

gr

8 Z

c

/y

20

1217000

1/2” Hex 

c

ap 

s

crew

gr

5 Z

c

/r

oH

s

13

1

1

17035

1/2” Hex 

c

ap 

s

crew

gr

5 Z

c

/ro

13

1

1

17121

1

1

17050

1

1

17051

1/2” Hex 

c

ap 

s

crew

gr

5 Z

c

/r

oH

s

13

1

1

17043

1

1

17124

1

1

17051

1/2” Hex 

c

ap 

s

crew

gr

5 Z

c

13

1

1

17036

051461

5/8” Hex 

c

ap 

s

crew

gr

5

11

40300259

31

battery box

item # Part #

desCriPtion

qty.

unit

1

baTTEry box  coMPlETE

1

Ea

2

130009201

baTTEry box assEMbly

1

Ea

3

130009408

anglE sUPPorT al 450523x36

1

Ea

4

130009200

fraME assEMbly oUTEr - baTTEry box

1

Ea

5

130009204

door assEMbly  (door, HIngE, HandlE & gaskET)

1

Ea

6

130009405

HIngE sTaInlEss 47007794x36”

1

Ea

7

47001498

HandlE  T  PolIsHEd sTaInlEss W/lock rH

1

Ea

8

47001499

gaskET - HandlE

1

Ea

9

47000921

Hold/back door 6lbs

1

Ea

10

44004079

sEal “d” .25 x .375

9

fT

11

47008674

PlUg  roUnd

2

Ea

4

10

5

3

2

1

7

8

9

6

x

11

nuts

1

2

3

4

5

9

8

7

6

ZP

 - ZI

nc

 P

la

TE

d

g

enuine 

o

EM Parts 

  1.800.233.4823

www

.morganolsonparts.com

dia

.

s

tandard

t

hread

fig

.

#8

#10

1/4”

5/16

3/8”

.44

1/2”

nylon

 lock

Ing

 n

UT

, HE

x

32

1

052266

nylon

 lock

Ing

 n

UT

, HE

x

24

1

40301303

nylon

 lock

Ing

 n

UT

, HE

x

 ZP

24

3

1

1

17307

nylon

 lock

Ing

 n

UT

, HE

x

 ZP

20

3

1

1

17310

nylon

 lock

Ing

 n

UT

, HE

x

 ZP

18

3

1

1

17838

nylon

 lock

Ing

 n

UT

, HE

x

 ZP

16

3

1

1

17344

lock

Ing

 n

UT

 HE

x

 flang

E .44-20 

ov

al

20

4

1217003

n

UT

s

E

r

T

 E

x

P

and

Ing

 nyl

 .275 

s

Q

20

5

40900006

n

UT

 non

 lock

Ing

24

2

1

1

17303

n

UT

 non

 lock

Ing

20

2

1

1

17312

n

UT

 non

 lock

Ing

16

2

1

1

17316

grade

 5

n

UT

 s

T

l

 lk

 lrg

 flg

 gd

5 .31-18

18

4

40100560

n

UT

 s

T

l

 HE

x

 lk

 b

 ZP

 .5 -13 

gr

 5

13

1

1

1

17283

18-8 

s

tainless

n

UT

 ss

 lock

Ing

32

3

1

1

17347

1

1

17699

n

UT

 ss

 lock

Ing

24

6

1

103354

n

UT

 ss

 lock

Ing

20

6

1

1

17336

n

UT

 ss

 non

 lock

Ing

20

7

40100044

n

UT

 ss

 acorn

 lo

W 

cro

W

n

20

8

40100061

s

peciality

c

H

ann

E

l

 n

UT

 WITH

 s

P

r

Ing  1 x 1-1/4”

20

9

47009988

32

g

enuine 

o

EM Parts 

  1.800.233.4823

www

.morganolsonparts.com

rivets

4

5

9

8

7

6

10

l

ength

m

agna

 l

o

CK

d

iameter

f

ig.

.25

.312

.375

.438

.44

.5

.562

.625

.687

.75

.875

1”

HU

ck

 r

6-4

.188

1

1

1

17084

1

1

17061

HU

ck

 r

8-6

.25

2

1

1

17087

P

ro

T

r

U

d

Ing

 HE

ad

.25

3

40200304

40200634

40200303

fl

U

s

H HE

ad

 b

6-4

.25

4

40200630

r

Iv

 al

 bra

IZE

r

 HE

ad

.125

5

1

1

17402

1

1

17404

1

1

17405

1

1

17406

r

Iv

 al

 bra

IZE

r

 HE

ad

 

.188

5

1

1

17351

1

1

17353

1

1

17355

1

1

17357

1

1

17359

1

1

17361

1

1

17363

1

1

17365

1

1

17368

r

Iv

 al

 bra

IZE

r

 HE

ad

.25

5

1

1

17380

1

1

17385

1

1

17382

1

1

17386

1

1

17395

r

Iv

 al

 bra

IZE

r

 HE

ad

 M

od

.25

5

40200213

40200214

1

1

17409

1

1

17410

1

1

17408

1

1

17869

1

1

17390

r

Iv

 al

 fla

T

 HE

ad

.125

7

85780100

r

Iv

 al

 fla

T

 HE

ad

.188

7

1

1

17434

1

1

17436

1

1

17438

1

1

17440

1

1

17442

r

Iv

 al

 fla

T

 HE

ad

 P

o

P

.25

7

40200630

r

Iv

 al

 do

ME HE

ad

 bl

Ind

.125

10

1

1

17464

r

Iv

 al

 do

ME HE

ad

 bl

Ind

.188

10

1

1

17456

1

1

17457

1

1

17458

1

1

17459

P

o

P

 al

 o

PE

n 

E

nd bl

Ind

.125

6

1

1

17421

P

o

P

 al

 o

PE

n 

E

nd bl

Ind

.188

6

1

1

17456

1

1

17457

1

1

17459

1

1

17458

P

o

P

 clsd

 black

8

40200629

40200631

sna

P

 f

as

T

n

E

r

9

40900925

b

U

lb

 T

y

PE 

bl

Ind

 w/W

as

HE

r

.188

10

40200621

40200501

1

2

3

33

w

ashers

1

2

3

4

5

9

8

7

6

g

enuine 

o

EM Parts 

  1.800.233.4823

www

.morganolsonparts.com

s

tandard

i/

d

fig

.

3/8

1/2

9/16

5/8

3/4”

7/8

1”

1-1/4”

1-3/4”

#10 

T

y

PE 

b

 fla

T

 W

as

HE

r

 ZI

nc

/ro

H

s

.190

1

1

1

17929

#10 

x

 1 

f

E

nd

E

r

 W

as

HE

r

 Z

c

.190

2

1

1

17950

#10 E

x

TE

rnal

 T

oo

TH 

l

/W Z

c

.190

3

1

1

17971

1/4 E

x

TE

rnal

 T

oo

TH 

l

/W Z

c

1/4

3

1

1

17975

1/4 

T

y

PE 

b

 narro

W 

fla

T

 W

as

HE

r

1/4

4

1

1

17941

1/4 U

ss

 fla

T

 W

as

HE

r

 Z

c

/ro

H

s

1/4

1

1

1

17953

40300918

1/4 

f

436 (

a

325) 

fla

T

 W

as

HE

r

 Z

c

/ro

H

s

1/4

1

40000047

fla

T

 W

as

HE

r

 .060 

THI

ck

 Z

c

/ro

1/4

1

1

1

17952

1/4 U

ss

 fla

T

 W

as

HE

r

1/4

1

1

1

17885

5/16 

s

P

l

IT

 lock

 W

as

HE

r

 Z

c

/ro

H

s

5/16

5

1

1

17965

5/16 U

ss

 fla

T

 W

as

HE

r

 Z

c

/ro

H

s

5/16

1

1

1

17955

3/8 U

ss

 fla

T

 W

as

HE

r

 Z

c

/ro

H

s

3/8

1

1

1

17957

3/8 

x

 1 

fla

T

 W

as

HE

r

 1/4 

TH

k

 nylon

3/8

6

40000038

1/2 

T

y

PE 

b

 r

E

g

U

lar

 fla

T

 W

as

HE

r

1/2

1

40000050

1/2 

T

y

PE 

b

 r

E

g

U

lar

 fla

T

 W

as

HE

r

 Z

c

1/2

1

1

1

17945

1/2 

T

y

PE 

b

 WI

d

E 

fla

T

 W

as

HE

r

 Z

c

/ro

H

s

1/2

1

1

1

17959

g

rade 8

1/4    

fla

T

 W

as

HE

r

 gr

 8 Z

c

/y

1/4

7

85761003

5/16  

fla

T

 W

as

HE

r

 gr

 8 Z

c

/y

5/16

7

1

1

17937

3/8    

fla

T

 W

as

HE

r

 gr

 8 Z

c

/y

3/8

7

40000046

1

1

17947

7/16  

fla

T

 W

as

HE

r

 gr

 8 Z

c

/y

7/16

7

1217002

1/2    

fla

T

 W

as

HE

r

 gr

 8 Z

c

/y

1/2

7

1

1

17943

85761009

s

tainless 18-8

#10 

x

 5/8 

bond

E

d

 s

E

al

E

r

 18-8 

ss

.190

8

85761250

40000053

1/4 

x

 5/8  

bond

E

d

 s

E

al

E

r

 18-8 

ss

1/4

8

40000051

3/8 

x

 3/4  

bond

E

d

 s

E

al

E

r

 18-8 

ss

3/8

8

40000054

3/8 

x

 1”    

bond

E

d

 s

E

al

E

r

 18-8 

ss

3/8

8

40000055

1/4 E

x

TE

rnal

 T

oo

TH 

ss

 l

/W Z

c

1/4

3

40000510

s

peciality

W

as

HE

r

 nylon

 .13 

x

 .62 I

d

 x

 1.38

od

5/8

9

137147429

34

1

2

3

4

5

9

8

7

6

s

C

rews

T/

c

 Thread 

c

utting

6 

l

obe

T

ype 

a

g

enuine 

o

EM Parts 

  1.800.233.4823

www

.morganolsonparts.com

l

ength

18-8 

s

tainless

d

iameter

f

ig.

.5

.625

.75

.875

1”

1-1/4”

1-1/2”

2-1/4”

2-1/2

3”

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 18-8 

ss

8 - 32

1

1

1

17716

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 18-8 

ss

10 - 24

1

1

1

17800

1

1

17814

40300498

40300451

1

1

17835

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 18-8 

ss

1/4 - 20

1

1

1

17857

1

1

17784

40300453

40300454

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 18-8 

ss

5/16 - 18

1

1

1

17928

PHI

ll

IP

s

 fla

T

 M/

s

 18-8 

ss

10 - 32

2

1

1

17830

1

1

17900

PHI

ll

IP

s

 fla

T

 M/

s

 18-8 

ss

10 - 24

2

1

1

17786

40300510

PHI

ll

IP

s

 fla

T

 M/

s

 18-8 

ss

1/4 - 20

2

40300809

1

1

17782

40300634

40300630

40300631

40300638

PHI

ll

IP

s

 fla

T

 M/

s

 18-8 

ss

3/8 - 16

2

1

1

17789

PHI

ll

IP

s

 ro

U

nd

 M/

s

 18-8 

ss

10 - 24

6

1

1

17209

6 

l

ob

E

 P

an 

T

/c M/

s

 18-8 

ss

1/4 - 20

9

1

1

17815

40300309

s

tandard 

s

teel 

r

o

hs

PHI

ll

IP

s

 ro

U

nd

 M/

s

 Z

c

/ro

H

s

  8 - 32

6

1

1

17839

PHI

ll

IP

s

 P

an

 TE

ks

/3 Z

c

/ro

H

s

10 - 16

5

1

1

17674

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 Z

c

/ro

H

s

10 - 24

1

1

1

17793

PHI

l

l

IP

s 

T

r

U

ss

 M/

s

 Z

c

/ro

H

s

10 - 32

1

1

1

17723

1

1

17688

1

1

17715

t

/C - 

t

hread Cutting

PHI

l

 P

an

       

T/

s

 T

y

PE 

a

  Z

c

10

8

1

1

17680

PHI

l

 T

r

U

ss

  T/

s

 T

y

PE 

a

  

blk

 

10

4

40300101

PHI

l

 P

an

       

T/

s

 T

y

PE 

a

  

blk

10

7

40300503

PHI

l

 P

an

       

T/

s

 T

y

PE 

a

 Z

c

12

8

1

1

17666

6 

l

ob

E

 P

an 

T

/c

1/4 - 20

9

85743152

1

1

17668

40300922

1

1

17684

40300042

35

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

36

37

eleCtriCal

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

item #

Part #

desCriPtion

qty.

unit

1

46024513

back UP alarM

1

fT

2

46023605

sWITcH rockEr dasH fan  on-off-on

1

fT

3

46023508

sWITcH cab doME laMP sPsT on-off

1

Ea

4

46023618

sWITcH rockEr acTUaTor HEaTEd MIrrors

1

Ea

5

46023611

sWITcH rockEr basE HTd/ MIrrors sPdT  on - on  

1

Ea

6

46030011

fan 2 sPEEd  270 cfM

1

Ea

7

46023310

sWITcH WIPEr on/off, WasH & sPEEd conTrol

1

Ea

8

46003017

laMP InTErMITanT WIPEr

1

Ea

9

46002427

laMP lIcEnsE PlaTE lEd clEar

1

Ea

10

46001905

laMP aUx sToP TUrn bar

1

Ea

11

46002209

laMP rEar coMbo lEd (sHoWn WITH groMMET 4600402

4

Ea

12

46001406

laMP b/U lEd    (sHoWn WITH groMMET 46004402)

2

Ea

13

46000615

laMP Park / TUrn fronT  lEd  (UsE groMMET 46004403)

2

Ea

14

46000213

laMP HEadlIgHT assEMbly

2

Ea

15

46026380

flasHEr for TUrn/TaIl lEd 

1

Ea

16

46001339

laMP clEarancE MarkEr lEd aMbEr

6

Ea

17

46001362

laMP clEarancE MarkEr lEd aMbEr

1

Ea

18

46001340

laMP clEarancE MarkEr lEd rEd

7

Ea

19

46019325

lock sEcd .180 bUllET M/fEM

1

Ea

20

46026432

PoWEr PoInT Usb  5v  3.1 aMP oUTPUT

1

Ea

21

46025303

sWITcH MagnETIc rEEd closEd looP

4

Ea

22

124091400

brackET MagnET door al .102x3.91x4.47 rH

1

Ea

23

074091402

brackET sWITcH al .102x2.5x3.62

2

Ea

24

124091401

brackET MagnET door al .102x3.91x4.47 lH

1

Ea

24

wiring harness

Page #

Part #

desCriPtion

qty.

unit

38

47004506

HarnEss PIgTaIl PUMP WIndoW WasHEr 

1

Ea

39

082091200

HarnEss PoWEr oPTIon froM baTTEry

1

Ea

40

090051201

HarnEss MIrror HEaTEd W/rkr sW

1

Ea

41

098084202

HarnEss fUsE cEnTEr 

1

Ea

42

098085201

HarnEss Hood  (for alUMInUM Hood)

1

Ea

43

124091200

HarnEss JPr lIfT gaTE door safETy

1

Ea

44

130087200

HarnEss rEar Wrg lH sIll

1

Ea

45

130087201

HarnEss rEar Wrg rH sIll

1

Ea

46-47

132093200

HarnEss roof 13/16'6" sPcl

1

Ea

48

133093201

HarnEss TransoM cHMsl

1

Ea

49-50

137391200

HarnEss roof To nosE

1

Ea

51-53

138084200

HarnEss coMMand cEnTEr fcc

1

Ea

54

162088201

HarnEss JUMPEr aUx baTTEry

1

Ea

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

38

39

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

40

41

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

42

43

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

44

45

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

46

47

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

48

49

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

50

51

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

52

53

wiring DiAgrAMS

wiring DiAgrAMS

Genuine OeM replaceMent parts 

1-800-233-4823

www.MOrGanOlsOnparts.cOM

54

55

wiring DiAgrAMS

wiring DiAgrAMS